成功的把會受氧氣干擾的因素解決，這對此二氧化碳感測器有很大的 助益。由於本感測器目前還處於實驗室使用階段上，因為此電位式二 氧化碳感測器在感測氣體時需要有水氣通過才能發揮感測能力。對於 此研究方面仍有很大發展性，像是我們可以在固態電解質裡面添加適 當保濕的材料進去，讓水氣分子可以保留在固態電解質薄膜內，而不 會影響到對二氧化碳感測，這樣就可以解決需要通水氣的問題。
本感測元件經過改良不僅不影響本身感測能力而且對於氧氣又 能有抵抗干擾的能力。再加上本感測器又是電位式訊號，如此搭配上 數位電子電路的設計便可將感測訊號即時顯現在顯示面板上，將之製 成輕、薄、短、小、價格低廉的數位型電位式二氧化碳感測器。日後 若運用在商業販售上，便會取代目前以紅外線為主的二氧化碳感測 器，而成為新主流的二氧化碳感測器。
---參考文獻---
參 考 文 獻
[1]. Fabrication amd Characterization of IrO2-Based Microsensors for Fast Detection of Carbon Dioxide，Jaw-Chyng LUE and Shuchi CHAO，Jpn.J.Appl.Phys.Vol.36(1997) pp,2292-2297
[2]. A simple laboratory procedure for packageing and testing part –fabricated gas microsensors，Schao，Meas.Sci.Technol.7(1996)
731-741
[3].Electrical Characteristics of WO3-Based CO2-Sensitive Solid-State Microsensor，
Shuchi Chao，Jpn.J.Appl.Phys.Vol.32(1993) pp.L1346-L1348
[4].Formation Process and Electrial Property IrO2 Thin Films Preparted by Reactive Sputtering，Takeshi Ishikawa，Yoshio ABE*，Midori Kawamura and Katsutaka Sasaki，Jpn.J.Appl.Phys.Vol.42(2003) pp.213-216
[5].Anodically Electrodeposited Iridium Oxide Films (AEIROF) from Alkaline Solutions for Electrochromic Display Devices，Kazusuke Yamanaka，Japanese
Journal Of Applied Physics Vol.28，No.4，April，1989，pp.632-637 [6].The Electrochemical Behavior of Anodically Electrodeposited Iridium
Oxide Films and the Reliability of Transmittance Variable Cells，Kazusuke Yamanaka，Japanese Journal Of Applied Physics，Vol.30，No.6，
June，1991，pp.1285-1289
[7].Electrical Characteristics of CO2-Sensitive Diode Based on WO3 and IrO2 for Microsensor Applications，Shuchi Schao，Jpn.J.Appl.Phys.Vol.37(1998) pp.L245-L247
[8].The Suitability of Ta2O5 as Solid State Ion-Sensitive Membrane，Utis
Teravaninthorn，Yuji MiYahara and Toyosaka Moriizumi，Japanese Journal Of Applied Physics Vol.26，No.12 December，1987，pp.2116-2120
[9].Oriented growth of Ta2O5 film induced by subtrate bias，A.P.Huang，
Sh.L.Xu.M.K.Zhu*，G.H.Li，T.Liu，B.Wang，H.Yan，Journal of Crystal Growth 255 (2003) 145-149
[10].Micropotentiometric Sensors，Hakhyunnam, Geun Sig Cha, TimthY D.
Strong, Student Member, IEEE,Jeonghan Ha, Jun Ho Sim, Robet W. Hower, Member, IEEE,Steven M. Martin, Student Member, IEEE, And Richard B. Brown, Senior Member, IEEE，Prcceeding of The IEEE，Vol.91，No.6，June 2003
[11].Stuides on the electrochemical approach to ion solvation，Kosuke Izutsu，Pure &
Appl.Chem，Vol.70，No.10 pp.1873-1880，1998
[12].Effect of coating thickness on the properties of IrO2-Ta2O5 anodes，J. Krya Sa, J. Maixner, R. MRAÂ Z, I. ROUSÏ AR，Journal Of Applied Electrochemistry 28
(1998) 369-372
[13].Development of Gas Sensor for Envionmental Protection，Noboru Yamazoe and Norio Miura，IEEE Transactions On Components, Packaging, And Manufacturing Technology-Part A. Vol. 18, No. 2, June 1995
[14].Gas Sensing Interface Of Solid Eletroyte Based Carbon Dioxide Sensors Attached With Metal Carbonate，Noboru Yamazoe and Norio Miura，The 8th International Conference on Solid-state Sensors and Actuators, and Eurosensors IX. Stockholm, Sweden, June 25-29, 1995
[15].Configuration for micro pH sensor，Y.J. Kim, Y.C. Lee, B.K. Sohn, C.S. Kim and J.H. Lee，Electronics Letters 16th October 2003 Vol. 39 No. 21
[16]. Potentiometric pCO2 sensor using polyaniline-coated pH-sensitive electrodes，Gang Cuia, Jin Seo Leea, Sang Jin Kima, Hakhyun Nama, Geun Sig Cha*a and Hai Dong Kimb，Analyst, 1998, 123, 1855–1859
[17].以濺鍍氧化銥薄膜製作微電極參考電極之研究，藍國能，指導教授:趙書琦博
[20].Chemical Sensing with Solid State Device，M .J.Madou and S.R.Morrison，
(1989)510
[21].Kazasuke Yamanaka，Jpn.J.Appl.Phys.30，No.6(1991)1285 [22]. Kazasuke Yamanaka，Jpn.J.Appl.Phys.28，No.4(1989)632
[23].Introduction to Solid State Physics，Charles Kittel，6th ed，John Wiley & Sons(SEA) Pte.Ltd (1991)
[24].Ph.Arquiant，A.van den Berg，B.H.van der Schoot，N,F.de Rooij，etc.
Sens & Actuators B，13-14 (1993) 340
---參考文獻---
[25].Reference Electrodes-Theory and Practice，David J.G Ives and George J.Jansz，
Academic Press，INC (1961)
[26].VLSI 製造技術，莊達人編著，高立圖書有限公司，中華民國90年9月20日第四 版
[27].G.K.Wertheim and H.J.Guggenheim，Phys.Rev.B，22，No.10(1980)4680
[28].W.Olthuis，M .A .M Robben，P .Bergveld，M .Bos and W.E.Van der Linden，Sens.&
Actu .B，2(1990) 247
Figure 2.2 氣體感測機制說明圖
Si Substrate
---圖表---
0.6 mm
(b) (a)
Figure 3.1 (a) microelectrode array pattern . (b) stainless mask .
0.4 mm 0.6 mm 0.4 mm 0.3
mm 0.6 mm 0.4
mm
0.4 mm
0.4 mm
Figure 3.2 The sputtering equipment setup.
Quartz cylinder shield Magnetron Sputter source
In line regulator RotaMeters Glass cylinder
(ψ=21cm)
Substrate Holder
Cooling water in
out Matching
Box RF generator
Vacuum Gauge Mechanical Pump
Ar Gas ring
Viton L-gasket
ThermoCouple Gauge
Heater power Supply
O2
Figure 3.3 真空換氣系統裝置圖 集氣瓶
抽氣幫浦 氣瓶
氣瓶閥
發泡器
閥門開關 開關閥
開關閥
矽油 氣壓計
Oxide Pt /Cr
SiO2 Si3N4
N type Silicon
Figure 3.4 Schematic side viewof the summarized process flow for the lift-off processes.
Positive Photoresist Coating
Exposure ＆ Development
Remove Photoresist Sputtering
Deposition Oxide
---圖表---
Silicon/SiO2/Si3N4
Pt /Cr flag
IrO2 thin film
(a)
(b)
(c)
(d)
PVA‧KHCO3
Ag epoxy Epoxy IrO2 thin film
Figure 3.5 Schematic side view and top view of the summarized process flow for the fabrication of a sensor.
(+) (-)
O-ring seal Plastics
Syringe needle inlet Syringe needle outlet
Epoxy
Ag epoxy Epoxy
PVA•KHCO3 Si Subtrate
IrO2
(e)
(f)
Epoxy
Figure 3.6 感測小流量二氧化碳實驗裝置圖
Syringe pump
N2
Flowmeter
DI water
Bubbler Electrometer
Keithley 617
Strip chat recorder
Gas-tight syringe
(-) (+)Vdrop
CO2
N2 carrier gas Switch valve
Figure 3.7 微量二氧化碳快速注射裝置圖
N2 carrier gas N2
Flowmeter
DI water
Bubbler Electrometer
Keithley 617
Strip chat recorder
(-) (+) Vdrop
CO2 Switch valve
---圖表---Two terminal method Potential steps
Potential uphill and downhill by gradually increasing and decreasing the percentage of CO2 in N2 gas at 1 atm ,298K and H2O saturation. The total flow rate is kept at 14 ml/min.
Figure 4.1 多濃度表現階梯電位圖
500 1000 1500 2000 2500 3000
0
Potential difference (mV)
Time(sec)
Two terminal method Potential steps
Potential uphill and downhill by gradually increasing and decreasing the percentage of CO2 in N2 gas at 1 atm , 298K and H2O saturation. The total flow rate is kept at 14 ml/min.
Figure 4.2 大面積多濃度表現階梯電位圖
0 500 1000 1500 2000 2500 3000
10
Potential difference (mV)
Time(sec)
---圖表---Two terminal method Characteristic
Potential vs. logarithmic concentration of CO2 . The average slope 14 mV/dec.
Figure 4.3 電位差 vs. 二氧化碳注射濃度對數圖
100 101
35 40 45 50 55 60 65 70 75
Potential difference (mV)
log [ % of CO2]
Minc = 33.46 mV/Dec increasing
Two terminal method Characteristic
Potential vs. logarithmic concentration of CO2 . The average slope 14 mV/dec.
Figure 4.4 大面積氧化銥的電位差 vs.二氧化碳注射濃度對數圖
100 101
35 40 45 50 55 60 65 70 75
Potential difference (mV)
log [ % of CO2]
Minc = 28.15 mV/Dec increasing
---圖表---Two terminal method
Potential variation with respect to reference electrode vs. time under repeated injections of 0.1ml CO2 under a constant flow of N2 and saturated with H2O. The Plot shows the device is rapidly response.
Figure 4.5 快速注射小量二氧化碳即時反應實驗圖 ( IrO2-Ta2O5)
0 200 400 600 800 1000 1200 1400 20
40 60 80 100 120
Potential difference (mV)
Time (sec) 0.1ml
Injection of CO2
Two terminal method
Potential variation of IrO2-Ta2O5 sensing electrode with respect to the refernce electrode vs. time under a series of fast , small quantities CO2
injections under a constant flow of N2 stream. The concentration of PVA·
KHCO3 used on sensing electrode section and reference electrode section were 2mM. The line in the insect figure has a slope of 2788.05 [mV * sec /log ( % CO2 in N2)].The N2 flow rate is kept at 28ml/min,1 atm , 298K , and H2O saturation.
Figure 4.6 多濃度低流量快速注射實驗 ( IrO2-Ta2O5 )
0 150 300 450 600 750 900 1050 1200 1350 0
20 40 60 80 100
Potential difference (mV)
Time (sec) Injection of CO2
0.2ml
0.010ml 0.025ml
0.05ml 0.06ml 0.08ml 0.1ml
Two terminal method
Potential curve shade area vs. logarithmic injected CO2 quantity under constant 14 ml/min N2 flow with H2O saturated at 1 atm, 298K. The slop is 2788.05 mV*sec/Dec.
Figure 4.7 積分面積 vs 快速注射二氧化碳氣體濃度對數圖
10-2 10-1
1500 2000 2500 3000 3500 4000 4500 5000 5500
intergrate area ( 60 mV*sec)
[ injected CO2 quantity (ml) ] Y = 7787.38 + 2788.05 X
Two terminal method
Potential variation with respect to the reference electrode vs. time under 0.1ml O2 injection with N2 flow at 1atm,298K,and H2O saturation. The N2 flow rate is kept at 14 ml/min.
Figure 4.8 氧化銥感測元件對氧氣干擾實驗圖 0.1ml
Injection of O2
-200 0 200 400 600 800 1000 1200
14 15 16 17 18 19 20 21 22 23 24 25
Time (sec)
Potential difference (mV)
---圖表---Two terminal method
Potential variation with respect to the reference electrode vs.
time under 0.1ml O2 injection with N2 flow at 1atm,298K,and H2O saturation. The N2 flow rate is kept at 14 ml/min.
Figure 4.9 氧化銥-五氧化二鉭感測元件對氧氣干擾實驗圖
0 150 300 450 600 750
39 42 45
Potential difference (mV)
Time (sec) Injection of 0.1ml O2 gas
Two terminal method
Potential variation with respect to the reference electrode vs.
time under 0.05 ml CO2 , 0.05 ml CO2 + 0.05 ml O2, and 0.05 ml CO2 + 0.05 ml H2 injection with N2 flow at 1atm, 298K,and H2O saturation. The N2 flow rate is kept at 14 ml/min.
Figure 4.10 檢測氧氣對元件干擾的混合氣體實驗圖
0 200 400 600 800 1000 1200
60 70 80 90 100 110 120 130
Potential differece (mV)
Time (sec) injection
0.05 ml CO2
0.05 ml CO2 + 0.05 ml O2
0.05 ml CO2 + 0.05ml H2
---圖表---The terminal method
Potential variation with respect to the reference electrode vs.
time under 0.05 ml CO2 , 0.05 ml CO2 + 0.05 ml O2, and 0.05 ml CO2 + 0.05 ml H2 injection with N2 flow at 1atm, 298K,and without H2O saturation. The N2 flow rate is kept at 14 ml/min.
Figure 4.11 檢測氧氣干擾混合氣體與無水氣條件下實驗
-100 0 100 200 300 400 500 600 700 800 900 1000 20
30 40 50 60 70
Potential difference (mV)
Time ( sec )
0.05 ml CO2 0.05 ml CO2 + 0.05 ml O2 0.05 ml CO2 + 0.05ml H2
Injection
Ι. IrO
2( iridium oxide ) properties :
1.結構 : rutile structure
2.分子量( Formula weight ) : 224.216 ( g/mol ) 3.物理特性( Physical properties ) :
․顏色( Colour ) : black or brown
․外觀( Appearance ) : crystalline solid
․熔點( Melting point ) : 1070 ( °C ) ( decomposes )
․密度( Density ) :11700 ( kg /m3 )
․電阻( resistivity ) : 3 ~ 6×10-5 ( Ωcm ) (室溫)
4.組成分析與氧化數( Element analysis and oxidation numbers ) : 成 分 百 分 比 氧 化 態 電 子 組 態
Ir 85.73 4 [Xe].4f14.5d5 O 14.27 -2 [He].2s2.2p6
Ir O
---附錄---